Carrier 30XA080-500 Fan User Manual


  Open as PDF
of 80
 
64
Table 5 — 30XA080-500 Electrical Data, Single Point (Standard Condenser Fan Motors)
LEGEND
NOTES:
1. Units are suitable for use on electrical systems where voltage supplied to the unit ter-
minals is not below or above the listed minimum and maximum limits. Maximum allow-
able phase imbalance is: voltage, 2%; amps 10%.
2. Cooler heater is wired into the control circuit so it is always operable as long as the
control power supply disconnect is on, even if any safety device is open.
3. For MCA that is less than or equal to 380 amps, 3 conductors are required.
For MCA between 381-760 amps, 6 conductors are required.
For MCA between 761-1140 amps, 9 conductors are required.
For MCA between 1141-1520 amps, 12 conductors are required.
Calculation of conductors required is based on 75 C copper wire.
4. Wiring for main field supply must be rated 75 C minimum. Use copper for all units.
a. Incoming wire size range for the terminal block is no. 4 AWG (American Wire Gage)
to 500 kcmil.
b. Incoming wire size range of non-fused disconnect with MCA up to 599.9 amps is
3/0 to 500 kcmil.
c. Incoming wire size range of non-fused disconnect with MCA from 600 to 799.9 amps
is 1/0 to 500 kcmil.
d. Incoming wire size range of non-fused disconnect with MCA from 800 to 1199.9 amps
is 250 kcmil to 500 kcmil.
5. Data provided circuit 1/circuit 2 where there are two circuits.
UNIT
30XA
UNIT VOLTAGE
NUMBER
OF
COND
FANS
NO HYDRONIC PACKAGE 5 HP PUMP, 3450 RPM 7.5 HP PUMP, 3450 RPM CONTROL CIRCUIT
V-Hz
(3 Ph)
Supplied
MCA MOCP
ICF Rec
Fuse
Size
MCA MOCP
ICF Rec
Fuse
Size
MCA MOCP
ICF Rec
Fuse
Size
Voltage
1 PH,
60 Hz
MCA
and
MOCP
Min Max WD XL WD XL WD XL
080
230-60 207 253 6 315.5 400 4
84.2 1170.2 350 — — — — — — — — — — 115 40
200-60 187 220 6 347.6 450 549.6 1338.6 400 — — — — — — — — — — 115 40
460-60 414 506 6 157.7 200 242.1 585.1 175 — — — — — — — — — — 115 40
575-60 518 633 6 121.2 150 191.9 465.9 150 — — — — — — — — — — 115 40
380-60 342 418 6183.5 250 289.7 704.7 225 — — — — — — — — — — 115 40
090
230-60 207 253 8 334.0 450 499.1 1185.1 400 350.0 450 515.1 1201.1 400 357.2 450 522.3 1208.3 400 115 40
200-60 187220 8 368.0 500 566.0 1355.0 450 385.7 500 583.7 1372.7 450 393.6 500 591.7 1380.7 450 115 40
460-60 414 506 8 167.0 225 249.6 592.6 200 175.0 225 257.6 600.6 200 178.6 225 261.2 604.2 200 115 40
575-60 518 633 8 128.5 175 197.8 471.8 150 134.9 175 204.2 478.2 150 137.7 175 207.0 481.0 150 115 40
380-60 342 4188194.5 250 298.6 713.6 225 204.2 250 308.3 723.3 225 208.6 250 312.6 727.6 250 115 40
100
230-60 207 253 8 364.6 500 536.7 1278.7 400 380.6 500 552.7 1294.7 450 387.8 500 559.9 1301.9 450 115 40
200-60 187220 8 401.3 500 607.8 1461.8 450 419.0 500 625.5 1479.5 500 427.0 500 633.5 1487.5 500 115 40
460-60 414 506 8 182.3 250 268.4 639.4 200 190.3 250 276.4 647.4 225 193.9 250 280.0 651.0 225 115 40
575-60 518 633 8 139.5 175 211.7 508.7 175 145.9 175 218.1 515.1 175 148.8 200 220.9 517.9 175 115 40
380-60 342 4188212.7 250 321.7 770.7 250 222.4 300 331.3 780.3 250 226.7 300 335.7 784.7 250 115 40
110
230-60 207 253 8 405.7 500 536.7 — 450 421.7 500 552.7 — 500 428.9 600 559.9 — 500 115 40
200-60 187220 8 446.2 600 607.8 — 500 463.9 600 625.5 — 600 471.9 600 633.5 — 600 115 40
460-60 414 506 8 202.4 250 268.4 639.4 225 210.4 250 276.4 647.4 250 214.0 300 280.0 651.0 250 115 40
575-60 518 633 8 155.5 200 211.7 508.7 175 161.9 225 218.1 515.1 200 164.8 225 220.9 517.9 200 115 40
380-60 342 4188236.4 300 321.7 770.7 300 246.1 300 331.3 780.3 300 250.4 350 335.7 784.7 300 115 40
120
230-60 207 253 8 438.6 600 569.6 — 500 454.6 600 585.6 — 500 461.8 600 592.8 —600 115 40
200-60 187220 8 482.2 600 643.8 — 600 499.9 600 661.5 — 600 507.8 600 669.4 — 600 115 40
460-60 414 506 8 218.4 300 284.4 655.4 250 226.4 300 292.4 663.4 250 230.0 300 296.0 667.0 300 115 40
575-60 518 633 8 168.4 225 224.5 521.5 200 174.8 225 230.9 527.9 200 177.7 225 233.8 530.8 200 115 40
380-60 342 4188255.3 350 340.6 789.6 300 265.0 350 350.3 799.3 300 269.4 350 354.7 803.7 300 115 40
140
230-60 207 253 10 534.7 800 796.7 — 700 550.7 800 812.7 — 700 557.9 800 819.9 — 700 115 40
200-60 187 220 10 588.5 800 906.1 — 700 606.2 800 923.8 — 700 614.1 800 931.8 —700 115 40
460-60 414 506 10 267.3 400 398.4 1030.4 350 275.3 400 406.4 1038.4 350 278.9 400 410.0 1042.0 350 115 40
575-60 518 633 10 205.0 300 315.5 821.5 250 211.4 300 321.9 827.9 250 214.3 300 324.7 830.7 250 115 40
380-60 342 418 10 311.2 450 478.9 1243.9 350 320.9 450 488.6 1253.6 400 325.3 450 493.0 1258.0 400 115 40
160
230-60 207 253 10 621.1 800 997.6 — 700 637.1 800 1013.6 — 800 644.3 800 1020.8 — 800 115 40
200-60 187 220 10 682.8 1000 1136.1 — 800 700.5 1000 1153.8 — 800 708.5 1000 1161.7 — 800 115 40
460-60 414 506 10 309.7 450 498.4 1306.4 350 317.7 450 506.4 1314.4 400 321.3 450 510.0 1318.0 400 115 40
575-60 518 633 10 238.1 350 396.3 1042.3 300 244.5 350 402.7 1048.7 300 247.4 350 405.6 1051.6 300 115 40
380-60 342 418 10 361.1 500 598.9 1577.9 450 370.8 500 608.6 1587.6 450 375.2 500 612.9 1591.9 450 115 40
180
230-60 207 253 12 673.2 800 935.2 — 800 — — — — — — — — — — 115 40
200-60 187 220 12 740.9 1000 1058.5 — 1000 — — — — — — — — — — 115 40
460-60 414 506 12 336.6 450 467.6 1099.6 400 — — — — — — — — — — 115 40
575-60 518 633 12 258.3 350 368.8874.8 300 — — — — — — — — — — 115 40
380-60 342 418 12 391.5 500 559.2 1324.2 450 — — — — — — — — — — 115 40
200
230-60 207 253 12 769.6 1000 1146.0 — 1000 — — — — — — — — — — 115 40
200-60 187 220 12 846.0 1000 1299.2 — 1000 — — — — — — — — — — 115 40
460-60 414 506 12 383.9 500 572.6 1380.6 450 — — — — — — — — — — 115 40
575-60 518 633 12 294.8 400 453.0 1099.0 350 — — — — — — — — — — 115 40
380-60 342 418 12 447.2 600 685.0 1664.0 500 — — — — — — — — — — 115 40
220
230-60 207 253 13 850.2 1200 1152.0 — 1000 — — — — — — — — — — 115 40
200-60 187 220 13 935.1 1200 1305.9 — 1200 — — — — — — — — — — 115 40
460-60 414 506 13 424.7 600 575.6 1383.6 500 — — — — — — — — — — 115 40
575-60 518 633 13 326.3 450 455.4 1101.4 400 — — — — — — — — — — 115 40
380-60 342 418 13 494.5 700 688.6 1667.6 600 — — — — — — — — — — 115 40
240
230-60 207 253 13 910.0 1200 1211.8 — 1200 — — — — — — — — — — 115 40
200-60 187 220 13 1001.1 1200 1371.8 — 1200 — — — — — — — — — — 115 40
460-60 414 506 13 455.0 600 605.9 1413.9 600 — — — — — — — — — — 115 40
575-60 518 633 13 349.6 450 478.7 1124.7 400 — — — — — — — — — — 115 40
380-60 342 418 13 529.5 700 723.5 1702.5 600 — — — — — — — — — — 115 40
260
460-60 414 506 15 516.5 700 777.6 1999.6 600 — — — — — — — — — — 115 40
575-60 518 633 15 396.4 500 616.2 1594.2 450 — — — — — — — — — — 115 40
380-60 342 418 15 600.2 800 933.9 2412.9 700 — — — — — — — — — — 115 40
280
460-60 414 506 16 549.7 800 810.9 2032.9 700 — — — — — — — — — — 115 40
575-60 518 633 16 422.1 600 641.9 1619.9 500 — — — — — — — — — — 115 40
380-60 342 418 16 638.7 800 972.4 2451.4 800 — — — — — — — — — — 115 40
300
460-60 414 506 16 610.9 800 810.9 2032.9 700 — — — — — — — — — — 115 40
575-60 518 633 16 468.7 600 641.9 1619.9 600 — — — — — — — — — — 115 40
380-60 342 418 16 710.3 1000 972.4 2451.4 800 — — — — — — — — — — 115 40
325
460-60 414 506 18 624.3 800 885.5 2107.5 700 — — — — — — — — — — 115 40
575-60 518 633 18 479.1 600 698.9 1676.9 600 — — — — — — — — — — 115 40
380-60 342 418 18 724.7 1000 1058.4 2537.4 800 — — — — — — — — — — 115 40
350
460-60 414 506 18 685.5 800 88
5.5 2107.5 800 — — — — — — — — — — 115 40
575-60 518 633 18 525.7 700 698.9 1676.9 600 — — — — — — — — — — 115 40
380-60 342 418 18 796.3 1000 1058.4 2537.4 1000 — — — — — — — — — — 115 40
400
460-60 414 506 20 746.6 1000 1007.8 2229.8 1000 — — — — — — — — — — 115 50
575-60 518 633 20 573.2 700 793.1 1771.1 700 — — — — — — — — — — 115 50
380-60 342 418 20 867.6 1000 1201.3 2680.3 1000 — — — — — — — — — — 115 50
450
460-60 414 506 22 880.0 1000 1080.0 2302.0 1000 — — — — — — — — — — 115 50
575-60 518 633 22 674.6 800 847.8 1825.8800 — — — — — — — — — — 115 50
380-60 342 418 22 1022.7 1200 1284.8 2763.8 1200 — — — — — — — — — — 115 50
500
460-60 414 506 22 931.3 1200 1131.3 2353.3 1200 — — — — — — — — — — 115 50
575-60 518 633 22 714.1 800 887.3 1865.3 800 — — — — — — — — — — 115 50
380-60 342 418 22 1082.4 1200 1344.5 2823.5 1200 — — — — — — — — — — 115 50
ICF — Instantaneous Current Flow
MCA — Minimum Circuit Amps
MOCP — Maximum Overcurrent Protection
WD — Wye-Delta
XL — Across-the-Line
 previous next