Heat & Glo LifeStyle 8000CL-IPI-T Indoor Fireplace User Manual


  Open as PDF
of 82
 
3
Heat & Glo • 6000CL-IPI-S, 6000CL-IPI-T, 8000CL-IPI-S 8000CL-IPI-T • 2165-900 Rev. S • 9/12
SafetyAlertKey:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
TableofContents
A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
B. Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1ListingandCodeApprovals
A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
B. Glass Specications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
C. BTU Specications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 7
E. Non-Combustible Materials Specication. . . . . . . . . . . . . . 7
F. Combustible Materials Specication . . . . . . . . . . . . . . . . . 7
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
H. Requirements for the Commonwealth of Massachusetts . . 8
User Guide
2OperatingInstructions
A. Gas Fireplace Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
B. Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
C. Fan Kit (optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
D. Clear Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
E. Decorative Doors and Fronts . . . . . . . . . . . . . . . . . . . . . . 10
F. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
G. Remote Controls, Wall Controls and Wall Switches . . . . . 10
H. IPI Battery Tray/Battery Installation . . . . . . . . . . . . . . . . . 11
I. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 11
J. Before Lighting Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . 11
K. Lighting Instructions (IPI) . . . . . . . . . . . . . . . . . . . . . . . . . 12
L. After Fireplace is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
M. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 13
3MaintenanceandService
A. Maintenance Tasks-Homeowner . . . . . . . . . . . . . . . . . . . 14
B. Maintenance Tasks-Qualied Service Technician . . . . . . 15
C. Refractory, Grate and Valve Assembly Removal . . . . . . . 16
D. Burner Identication/Verication . . . . . . . . . . . . . . . . . . . . 17
Installer Guide
4GettingStarted
A. Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 18
B. Design and Installation Considerations . . . . . . . . . . . . . . 19
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 19
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . 19
5FramingandClearances
A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . 20
B. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 21
C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
D. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 22
6TerminationLocations
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 23
7VentInformationandDiagrams
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
B. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
C. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
D. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
E. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
8VentClearancesandFraming
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 37
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 37
C. Install the Ceiling Firestop . . . . . . . . . . . . . . . . . . . . . . . . 38
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 39
E. Installing the Optional Heat-Zone
®
Gas Kit . . . . . . . . . . . . . 39
9AppliancePreparation
A. Top Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
B. Rear Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
C. Installing the Non-combustible Board. . . . . . . . . . . . . . . . 42
D. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 42
10InstallingVentPipe(DVPandSLPPipe)
A. Assemble Vent Sections (DVP Pipe Only) . . . . . . . . . . . . 43
B. Assemble Vent Sections (SLP Pipe Only) . . . . . . . . . . . . 44
C. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 44
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 45
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 45
F. Install Decorative Ceiling Components (SLP only) . . . . . . 46
G. Install Metal Roof Flashing . . . . . . . . . . . . . . . . . . . . . . . . 47
H. Assemble and Install Storm Collar . . . . . . . . . . . . . . . . . . 47
I. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 48
J. Install Decorative Wall Components (SLP only) . . . . . . . . 48
K. Heat Shield Requirements for Horizontal Termination . . . 48
L. Install Horizontal Termination Cap (DVP and SLP Pipe) . 49
11GasInformation
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 50
12ElectricalInformation
A. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
B. IntelliFire Plus
TM
Ignition System Wiring . . . . . . . . . . . . . . 51
C. Optional Accessories Requirements . . . . . . . . . . . . . . . . 51
D. Electrical Service and Repair . . . . . . . . . . . . . . . . . . . . . . 52
E. Junction Box Installation. . . . . . . . . . . . . . . . . . . . . . . . . . 52
F. Wall Switch Installation for Fan (Optional) . . . . . . . . . . . . 52
 previous next