Filter
Top Products
2
TABLE OF CONTENTS
Packaging .........................................Page 2
Introduction ......................................Page 2
General Information
..........................Page 2
Massachusetts and New York
Requirements
................................Page 4
Cold Climate Insulation
.....................Page 5
Manufactured Home Requirements
..Page 5
Location ............................................Page 5
Vent Termination Clearances
............Page 6
Minimum Clearances to Combustibles
Page 8
Detailed Installation Steps
.................Page 9
Typical Installation Sequence
...........Page 9
Step 1. Framing
...............................Page 9
Fireplace and Framing Specifications
..Page 10
Step 2. Routing Gas Line
................Page 11
Proper Sizing of Gas Line
..................Page 11
Step 3. Install the Vent System
.......Page 12
Vertical Termination Systems
............Page 13
Vent Section Length Chart
................Page 13
Vertical Vent Tables and Figures
........Page 16
Horizontal Termination System
.........Page 17
Horizontal Vent Tables and Figures
...Page 19
Step 4. Field Wiring
.........................Page 21
Step 5. Removing Glass Door
Frame Assembly
...........................Page 22
Step 6. Connecting Gas Line
...........Page 22
Step 7. Checking Appliance
Operation
......................................Page 23
Step 8. Installing Logs and Panels
..Page 24
Step 9. Installing Glass Door
..........Page 26
Step 10. Burner Adjustments
............Page 26
Finishing Requirements
....................Page 28
Step 11. Attaching Safety in
Operation Warnings ............... Page 29
Installation Accessories
....................Page 30
Gas Conversion Kits .................. Page 31
This manual is part of a set of two supporting
this product. Refer to manual 875,027M for
Care and Operation information.
Please read and understand these
instructions before beginning your
installation.
PACKAGING
The assembled vented gas fireplace is pack-
aged with:
1 - one envelope located in the firebox contain
-
ing the literature package, which consists of
the care and operation manual, installation
instructions, safety in operation warning
labels and warranty
2- one bag of glowing embers and volcanic
stone
3 - one of the following brick liner kits:
a. Brick Liner Kit, Rustic
b. Brick Liner Kit, Herringbone
c. Brick Liner Kit, Old Cottage
d. Brick Liner Kit, Black.
e. Brick Liner Kit, Red Rustic
f. Brick Liner Kit, Red Herringbone
4 - one of the following log sets:
a. Birch Log set
b. Oak Log set
5 - pull screen
6 - door modesty shield
INTRODUCTION
The Millivolt appliances are designed to operate
on natural or propane gas and have a millivolt
gas control valve with piezo ignition system.
The
Electronic appliances are designed to
operate on natural or propane gas and have a
electronic intermittent pilot ignition system. No
external electrical power is required to operate
these units.
These vented gas fireplaces are sealed com
-
bustion gas fireplaces designed for residential
applications.
Use Only These Approved Vent Components
- These fireplaces are designed, tested and
listed for operation and installation with,
the following (8" inner and 11" outer) vent
components only:
•
Secure Vent™ Direct Vent System Compo-
nents manufactured by Security Chimneys
International.
These approved vent system components are
labeled for identification. DO NOT use any
other manufacturer’s vent components with
these appliances.
WARNING
Young children should be care-
fully supervised when they are
in the same room as the appli-
ance. Toddlers, young children
and others may be susceptible
to accidental contact burns. A
physical barrier is recommended
if there are at risk individuals in
the house. To restrict access to
a fireplace or stove, install an
adjustable safety gate to keep
toddlers, young children and
other at risk individuals out of
the room and away from hot
surfaces.
AVERTISSEMENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu’ils
se trouvent dans la même pièce
que l’appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s’ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d’installer une barrière physique
si des personnes à risques habi-
tent la maison. Pour empêcher
l’accès à un foyer ou à un poêle,
installez une barrière de sécu-
rité; cette mesure empêchera les
tout petits, les jeunes enfants et
toute autre personne à risque
d’avoir accès à la pièce et aux
surfaces chaudes.
GENERAL INFORMATION
Children and adults should be alerted to the
hazards of high surface temperature and
should stay away to avoid burns or clothing
ignition.
Les enfants et les adultes devraient être infor-
més des dangers que posent les températures
de surface élevées et se tenir à distance afin
d’éviter des brûlures ou que leurs vêtements
ne s’enflamment.
DO NOT ATTEMPT TO ALTER OR MODIFY
THE CONSTRUCTION OF THE APPLIANCE OR
ITS COMPONENTS. ANY MODIFICATION OR
ALTERATION MAY VOID THE WARRANTY,
CERTIFICATION AND LISTINGS OF THIS
UNIT.