Heatiator BIR42 Indoor Fireplace User Manual


  Open as PDF
of 56
 
48
A. Gas Log/Lighter Provision
WARNING! Fire and/or Asphyxiation Risk! Use with solid
wood fuel or decorative gas appliance only. Gas re gener-
ates fumes.
 install unvented gas logs
• Damper must be locked fully open when gas logs are
installed
Firebox
Repack
insulation
knockout
Combustible
materials
Maintain air clearance
to combustibles.
Gas line
Combustible materials
may be located at zero
clearance to gas line
beyond 4 in. (102 mm)
from fireplace side.
Gas line
1 1/2 in. (38 mm)
air space around
pipe
Refractory
Seal with
fireplace mortar
or non-combust-
ible sealant
4 in.
(102 mm)
Outer shell
of fireplace
Figure 13.1 Gas Line Installation
13
Accessories
B. Wood Burning Inserts
Acertiedgasloglighterordecorativegaslogsetcanbe
installedinthisreplace.
• Maximuminputis150,000BTU/hr.
• DecorativegasappliancemustbecertiedtoANSI Z21.60
“StandardforDecorativeGasAppliancesforInstallation
inVentedFireplaces”.
• MustbeinstalledinaccordancewiththeNational Fuel
Gas Code, ANSI Z223.1.
• Agaslogsetmustincorporateagasshutoff.
• Gaslogsetrequiresthedampertobelockedfullyopen.
• Alistedautomaticdampersystemwithsafetyinterlockmay
beusedinthisreplacewithonlycompatible,listedgaslog
sets.Seedampersystemmanufacturer’sinstructions.
• Knockoutsareprovidedonbothsidesofthereplacefor
1/2in.(13mm)ironpipe.
• Alocatingdimple(seeFigure13.2)islocatedonbothsides
ofthereplaceinthemoldedbrickpanelsfordrillinga1
in.(25mm)diameterholeforinstallationofagasline.
Afterthepanelisinstalled,drilltheholeforthegasline.
• Sealpanelaround pipewithreplacemortaror ahigh
temperature,non-combustiblesealant.
WARNING! Risk of Fire! Improper installation of wood
inserts may cause replace or chimney system to overheat.
Ifawoodburninginsertisbeinginstalledinthisreplace,
Hearth&HomeTechnologiesrecommendsfullrelineofthe
chimney.
• Coolingairopeningsatthetopofthechimneymustnot
beobstructedinanymanner.
• Hearth&HomeTechnologiesrecommendssecuringthe
relineatthetopoftheueandusingthecapcertiedfor
usewiththisreplacesystem.
Gas Line
Dimple
Gas Line
Dimple
Figure 13.2 Gas Line Dimples
Heatilator•BirminghamBIR42•4059-308RevJ•1/11
 previous next