R
R
R
September 1, 2008
7001-142D
Page
Santa Fe Pellet Stove
Section 1: Listing and Code Approvals
A. Appliance Certications ......................4
B. Mobile Home Approved ......................4
C. Glass Specications ............................4
D. Electrical Rating ..................................4
E. BTU & Efciency Specications ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations ....................................5
B. Fire Safety ..........................................5
C. Tools & Supplies Needed ...................6
D. Measuring Standards..........................6
E. Inspect Appliance & Components
and Pre-Use Check List ......................6
Section 3: Dimensions & Clearances
A. Appliance Dimensions ........................7
B. Clearances to Combustibles ...............8
C. Hearth Requirements..........................9
Section 4: Vent Information
A. Chimney & Exhaust Connection .........10
B. Venting Termination Requirements ....10
C. Equivalent Feet of Pipe .......................11
D. Pipe Selection Chart ............................11
Section 5: Venting Systems
A. Alcove .................................................12
B. Through the Wall .................................1
C. Vertical ................................................14
D.
Through the Wall & Vertical ................14
E. Masonry ..............................................15
F. Alternate Masonry ...............................15
Section 6: Mobile Home ..................................16
Section 7: Appliance Set-Up
A. Outside Air Kit .....................................17
B. Top Vent Adapter ................................18
C. Log Set Placement ..............................19
D. Grille & Trim Ring Installation .............20
E. Thermostat Installation ........................21
Section 8: Operating Instructions
A. Fuel Size & Material ............................22
B. General Operation Information ...........22
C. Before Your First Fire .........................2
D. Starting Your First Fire ........................2
E. Fire Characteristics .............................2
F. Feed Rate Adjustment .......................2
G. Ignition Cycles ....................................24
H. Frequently Asked Questions...............24
Section 9: Troubleshooting ............................25-27
Section 10: Maintaining & Servicing Appliance
A. General Maintenance & Cleaning .......28-1
B. High Ash Fuel Content Maintenance ..2
C. Blower & Snap Disc #2 Replacement .-4
D. Igniter Replacement ............................5
E. Bafe & Brick Removal .......................5
F. Bafe & Brick Replacement ................6
G. Glass Replacement .............................7
Section 11: Reference Material
A. Component Functions.........................8-9
B. Component Locations .........................40
C. Exploded Drawings .............................41-42
D. Service Parts & Accessories ...............4-44
E. Service & Maintenance Log ................45
F. Warranty Policy ...................................46-47
G. Contact Information .............................48
TABLE OF CONTENTS