Quadra-Fire CASTILEI-CE-MBK Indoor Fireplace User Manual


  Open as PDF
of 36
 
R
October 27, 2011
Page29
Castile & Santa Fe CE Insert
7069-101B
C. Door Handle Removal
1. Opentheouterdoor.
2. Unlatchandopenthereboxdoor.
3. Continuetoturnhandleuntilitisfreefromtherebox
door.
D. Door Removal
1. Opentheouterdoor.
2. Unlatchandopenthereboxdoor.
3. Liftthereboxdoorup,freeingitfromthereboxhinges.
E. Adjustable Hearth Support
Size: 229mm d x 1143mm w, 51mm to 254mm
Height Adjustment
Included in Kit: (1)trimtop,(1)trimfront,(2)trimsides,
double-sidedtape(alreadyinstalled)
Tools Needed: Phillipsheadscrewdriver,sheetmetal
shears,measuringtape,gloves
1. The10screwsoneachsetofscissorswillalreadybe
loosewhenshipped.Figure 32.1.
2. Expandscissorstodesiredheight.Tightenscrewsto
holdinplaceusingPhillipsheadscrewdriver.
3. Measure front and side trims to required height
tocover scissorsandmark piecesforcutting. Cut
excessmaterialfromtopoftrim’sedge,notbottom.
Thisedgewillbesharp;wearglovestopreventinjury
toyourhands. Figure 32.2.
4. Usingsheetmetalshears,cuttrimalongthemarked
edge.The cutedgets underlipof toptrim,so it
allowsforsomevarianceinyourstraightedge.
5. Thedouble-sidedtapethatholdsfrontandsidetrims
toscissorshasapowerfulbondingadhesive.Adjust-
mentsareextremelydifcultoncetrimhasadheredto
tape.Doadryrunrstwithoutremovingpaperfrom
tape.
6. Placecutedgeoftrimundertoplipandintoposition
onscissors.Placesidepiecesonrstandthenfront
piece.Thefrontpieceoverlapssidepieces.
7. Onceyouaresatisedwiththepositioning,remove
trimandsetaside.
8. Remove the paper from double-sided tape that is
toaccepttrimside.Alignsideandthenpresshard
againsttapetosecuresidepiece.Repeatforother
side.Installfronttrimpiecelast.
9. Thereare3holesinthebackangeofthetoptosecure
ittothewallifnecessary.Usetheappropriatefastener
forthetypeofwallmaterial,i.e.,brick,sheetrock,etc.
NOTE:9.5mmthicktileorlikematerialcanbecuttosize
andtunderlipoftoptrimedgeforadecorativetouch.
Figure 32.3.
Figure 32.1
Figure 32.2
Figure 32.3
WARNING
Sheetmetaltrimedgeswillbesharp.
Forsafetypurposesweargloves.
Injurycanoccur.
DOUBLE-SIDEDTAPE
DOUBLE-SIDEDTAPE
SCREWS ARE CIRCLED
EXPLODED VIEW OF SCISSORS
Decorative tile
may be installed
INSTALL FRONT TRIM LAST.
CORNERS OVERLAP SIDE
TRIM PIECES
EXPAND SCISSORS TO DESIRED HEIGHT
CUT TOP EDGE OF TRIM,
NOT BOTTOM EDGE
 previous next