Filter
Top Products
3
AFII Burner Manual
To the Owner:
Thank you for purchasing a Beckett
burner for use with your heating appliance.
Please pay attention to the Safety Warnings
contained within this instruction manual.
Keep this manual for your records and
provide it to your qualifi ed service agency
for use in professionally setting up and
maintaining your oil burner.
Your Beckett burner will provide years of
effi cient operation if it is professionally
installed and maintained by a qualifi ed
service technician. If at any time the burner
does not appear to be operating properly,
immediately contact your qualifi ed
service agency for consultation.
We recommend annual inspection/
service of your oil heating system by a
qualifi ed service agency.
Daily – Check the room in which your
burner/appliance is installed. Make sure:
Air ventilation openings are clean and
unobstructed
Nothing is blocking burner inlet air
openings
No combustible materials are stored
near the heating appliance
There are no signs of oil or water
leaking around the burner or appliance
Weekly
Check your oil tank level. Always
keep your oil tank full, especially
during the summer, in order to prevent
condensation of moisture on the inside
surface of the tank.
y
y
y
y
y
Remainder of manual to be used ONLY BY
QUALIFIED SERVICE TECHNICIANS
▼
▼
Contents
General Information ....................................................4
Hazard Defi nitions ........................................................................ 4
Inspect/Prepare Installation Site ................................5
Clearances to Burner and Appliance ............................................. 5
Combustion Chamber and Burner Retrofi tting .............................. 5
Inspect Chimney or Direct Vent System ........................................ 5
Combustion Air Supply Information ............................................... 7
Direct/Sidewall Venting Application .............................................. 7
Prepare the Burner ......................................................8
General ......................................................................................... 8
Installing the Oil Tank and Supply System .................................... 8
Fuel Line Valves and Filter ........................................................... 8
Mount Burner on Appliance ........................................................... 9
Connect Fuel Lines ....................................................................... 9
Wire Burner ..................................................................9
Burner packaged with appliance ................................................... 9
Burner installed at jobsite .............................................................. 9
Special wiring required with covered burners ............................... 9
Burner Controls .........................................................10
GeniSys Model 7505 Control ...................................................... 10
Features ...................................................................................... 10
Wiring .......................................................................................... 10
Reset Button Operation ............................................................... 12
Wire Burner ................................................................................. 14
Start Up Burner and Set Combustion ......................14
Set combustion with instruments ..................................... 14
Perform Regular Maintenenance .............................15
Shutting the Burner Off ............................................................... 16
Removing Nozzle Line for Service .............................................. 16
Nozzle Installation ...................................................................... 16
Check/Adjust Electrodes ............................................................. 17
Blower Wheel Replacement ........................................................ 17
Replacement Parts ....................................................19
Limited Warranty Information ..................................20