Filter
Top Products
30 Maintenance
Travis Industries Newport 290902
Yearly Maintenance (or every two tons) - Continued
Check for Air Leaks Around the Door, Glass, and Ashpan
! Air leaks into the firebox will decrease the stove's performance greatly, leading to excessive
sooting, inefficient burning, and perhaps a malfunction.
• Test the door seal by shutting the door on a dollar bill in various locations. If the bill can be easily
slid out, air may be leaking around the door seal – inspect the door gasket and door catch
carefully.
• Inspect the door gasket to make sure it is fully attached. Use stove gasket cement to re-attach if
necessary. If the door gasket is worn or flattened, replace.
• Check the door to make sure it latches correctly. Slight adjustments can be made to the door
catch if necessary (do not over-tighten this catch, an over-tightened catch will damage the door).
The latch should engage with a slight amount of resistance, yet not be difficult to engage.
• If the glass is cracked, replace. The glass is held in place by glass clips that are underneath the
airwash brackets. See the illustration below for details.
• Remove the ashpan and inspect the gasket around the perimeter of the ashpan. Re-attach, or
replace the gasket if necessary.
Door Gasket
Airwash Bracket
Door
Frame
Gold Door
Glass (with
channel gasket)
Door
Gasket
Glass Clip
Airwash Bracket
Glass
Clip
5/16" Nutdriver
Attachment
Nuts
Replacement Parts
Air Control Restrictor 93005061 Draft Flow Tubing 99300164
Ash Door, Dump Plate 93005051 Exhaust Adapter, Pellet, Vertical 99300137
Ash Dump Seal Plate 93005052 Exhaust Blower Gasket (Between Blower & Stove) 90-0392
Ashpan, Pellet 93005050 Fuse Holder, Pellet 99300570
Ashtrap Clean Out Doors 93005054 Fuses, Pellet, 5-Amp, Pkg Of 5 93-0695
Auger Assembly, Complete 93005092 Gasket, Exhaust Blower (Between Motor & Housing) 99300135
Auger Bushing, Lower, With Plate 93005094 Glass, Pellet, Front 93005080
Auger Bushing, Upper, With Plate 93005093 Glass, Pellet, Side 93005081
Auger, Flight Only 93005091 Grill, Pellet, Black 93005035
Auger Motor 90-0191 Handle, Hopper Lid 93005040
Blower, Convection 98900755a Hinge Plate Assembly 93005082
Blower Convection, Mounting Grommets 93005017 Hopper Lid, Newport (Avanti) Pellet Stove 93005022
Blower, Convection, Mounting Plate 93005016 Ignitor 99300148
Blower, Exhaust 90-0391 Manual, Newport (Avanti PS) 1997 93508074
Brush, Pellet Stove, Bottle Brush Style 93005531 Motor Stop, 1997 Pellet Stove & Insert 93005095
Brush, Pellet Stove, Broom Style 93005530 Outside Air Kit 99200136
Burn Pot, Pellet, Removable 99300170 Pedestal Assembly 93005023
Control Board, Pellet, Electronic 93005000 Shell, Newport (Avanti) Pellet , Left Side 93005020
Door Gasket, Pellet 93005085 Shell, Newport (Avanti) Pellet, Right Side 93005021
Door, Newport (Avanti) Pellet, Complete 99300522 Snap Disk, 120 Degree - 2 Prong 98900720
Door Key 93005010 Snap Disk, 1997 Pellet, Ceramic, 120 Degree 100-00232
Door Latch Hook 93005011 Snap Disk, Pellet, Hopper, 200 Deg. 91-1791
Door Roller Plate Assembly 93005012 Wiring, Electric Power Cord 93005015
Draft Flow Switch 93005060 Wiring Harness 93005013