Filter
Top Products
22
OPERATING INSTRUCTIONS
For Your Safety Read Before Operating
!
WARNING
If you do not follow these instructions exactly,
a fi re or explosion may result causing property
damage, personal injury or loss of life.
Some boilers are equipped with an intermittent ignition A.
device which automatically lights the pilot. Do not try
to light the pilot by hand.
Some boilers are equipped with a continuous pilot and
must be manually lighted. (See lighting instructions on
page 23.) A match holder is included in the parts bag.
BEFORE OPERATING smell all around the appliance B.
area for gas. Be sure to smell next to the fl oor because
some gas is heavier than air and will settle on the fl oor.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.•
Do not touch any electric switch; do not use any phone •
in your building.
Immediately call your gas supplier from a neighbor’s •
phone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the fi re •
department.
Use only your hand to push in or turn the gas control C.
knob. Never use tools. If the knob will not push in or
turn by hand, don’t try to repair it, call a qualifi ed ser-
vice technician. Force or attempted repair may result in
a fi re or explosion.
Do not use this appliance if any part has been under D.
water. Immediately call a qualifi ed service technician
to inspect the appliance and to replace any part of the
control system and any gas control which has been
under water.
INTERMITTENT IGNITION BOILER - VR8204A/VR8304M GAS VALVE OPERATING INSTRUCTIONS
STOP! Read the safety information on this page.
1.
Set the thermostat to lowest setting.
2.
Turn off all electric power to the appliance.
3.
This appliance is equipped with an ignition device which
4.
automatically lights the pilot. Do not try to light the
pilot by hand.
Remove lower front panel.
5.
Rotate the gas control knob clockwise
6.
to“OFF”.
Wait fi ve (5) minutes to clear out any gas. Then smell
7.
for gas, including near the fl oor. If you smell gas,
STOP! Follow “B” in the safety information on this page
If you don’t smell gas, go to next step.
Rotate the gas control knob counterclockwise
8.
to “ON.”
Replace lower front panel.
9.
Turn on all electric power to the appliance.
10.
Set thermostat to desired setting.
11.
If the appliance will not operate, follow the instructions
12.
“To Turn Off Gas To Appliance” and call your service
technician or gas supplier.
TO TURN OFF GAS TO APPLIANCE
Set the thermostat to lowest setting.
1.
Turn off all electric power to the appliance if service is
2.
to be performed.
Push in gas control knob slightly and turn clockwise
3.
to “OFF” Do not force.