Filter
Top Products
Installation Instructions (cont'd)
Installation Checklist
BEFORE LIGHTING THE PILOT:
VENT PIPETO
OUTDOORS
• Check the gas lines for leaks.
a. Use a soapy water solution. DO NOT test for gas leaks
usinga match or open flame.
b. Brush the soapy water solution on all gas pipes, joints and
fittings.
c. Check for bubbling soap. This means you have a leak.
Turn "OFF" gas and make the necessary repairs.
d. Recheck for leaks.
e. Rinse off soapy solution and wipe dry.
• Is the new temperature-pressurerelief valveproperly installed
and piped to an adequate drain? See "Temperature-Pressure
Relief Valve"section.
• Are the cold and hot water lines connected to the water
heater correctly? See "Water Piping" instructions in the
"Installing the New Water Heater" section.
• Is the water heater completely filled with water? See "Filling"
instructions in the "Installing the New Water Heater" sec-
tion.
• Will a water leak damage anything? See the "Locating the
New Water Heater" secnon.
Is there proper clearance between the water heater and any-
thing that might catch fire?See the "Locating the New water
Heater" section.
Do you have adequate ventilation so that the water heater
will operate properly? See "Combustion Air and Ventilation"
in the "Locat'ng the New Water Heater' section.
Is the draft hood vent ppiingp roperly secured_.See "Venting"
instructions in the "Installing the New Water Heater" sec-
tion.
Is there proper clearance between the vent pipe and anything
that might catch on fire? See "Venting" instructions in the
"Installing the New Water Heater" secnon.
Is the vent pipe properly sloped and does the vent terminate
outdoors? See "Venting" instructions in the "Installing the
New Water Heater" section.
Do you need to call your gas company to check the gas pipe
and its hookup?
HOT
SHUTOFFVALVE
DRIP !
(Sediment trap)
PIPECAF
SHUTOFF
VALVE
GASSUPPLY
COLD
TEMPERATURE-
PRESSURERELIEF
VALVE
DISCHARGE PIPE
(Do not capor plug)
"AUTONATIC STORAGE WATER "NnTL"
RRATL;'R" SUITABLE FOR WATER
(POTABLB) _TZ.G O.LY t,t,,_)}
_o ANSi1 10
I f I
Id4_lk_ Ph'_O_TATIC OAS _44JI_E lq W C
P_i_ w_c w_c_ wc
MODEL RATING PLATE
20