![](http://pdfasset.owneriq.net/a/32/a3254bf1-c218-48d5-88e5-78a85376c9e6/a3254bf1-c218-48d5-88e5-78a85376c9e6-bgb.png)
vii
i. Cold Coolant – Liquid nitrogen, a cryogenic liquid, is used in traps. If it is splashed on body tis-
sues or eyes, it can cause severe frostbite or blindness. The extremely low temperature of lique-
fied nitrogen can cause skin damage similar to high temperature burns. Contact with the cold gas
evolving from the liquid may produce the same effect. Delicate tissues, such as the eye tissues,
are most easily damaged by exposure to cold gas or liquid. To minimize the risk of hazardous con-
tact of cold gaseous nitrogen with any part of the body, wear personal safety equipment recom-
mended for use with cryogenic materials including face shield, full-sleeved lab coat, and clean, dry
gloves which fit loosely so they can be thrown off quickly if frozen by contact with the gas.
j. Asphyxiation – If a large amount of liquid nitrogen is spilled in a small, poorly ventilated room or
equipment, death from suffocation can result. All diffusion pumps are typically cleaned with ace-
tone or alcohol. Acetone, alcohol, and most other solvents are very volatile (unstable). During
cleaning, the volatility of these cleaners may permit their gases to displace air and its life-support-
ing oxygen which could cause death or serious injury by asphyxiation. Always ensure that clean-
ing operations are performed in large, well-ventilated areas.
j. While still hot, the diffusion pump may also contain decomposed and/or overheated pump oils
which can also be an asphyxiant.
k. Large, Heavy Weights – Diffusion pumps larger than 10 inches in diameter require power-assist-
ed equipment and the use of trained moving/installation personnel in order to avoid dropping, slip-
ping, and/or overturning the pump thus severely injuring personnel. Check weight of equipment
before lifting and do not stand under equipment being moved.