Filter
Top Products
Table of Contents 3
© Travis Industries 4070806 100-01191_000
Introduction
Introduction......................................................2
Important Information .........................................2
Safety Precautions
Safety Precautions ............................................4
Specifications
Heating Specifications........................................6
Dimensions.......................................................6
Electrical Specifications......................................6
Fuel.................................................................6
EPA Compliance................................................6
Installation
Before You Begin...............................................7
Packing List......................................................7
Installation Options............................................7
Planning The Installation .....................................7
Stove Placement ...............................................7
Floor Protection Requirements..............................7
Clearances - Straight Installation ..........................8
Clearances - Corner Installation............................8
Venting the Pellet Stove......................................9
Maximum Venting Distance .............................9
Pellet Vent Type............................................10
Installing the Pellet Vent.................................10
Pellet Vent Termination...................................10
Mobile Home Requirements..................................11
Outside Air (used for combustion) .........................11
Alcove Installation Requirements..........................12
Baffle Installation...............................................12
Door Seal Verification .........................................12
Restrictor Adjustment.........................................12
Thermostat Installation .......................................13
Installation Example: Direct "Through-the-wall"
Installation .......................................................14
Installation Example: Interior Vertical Installation ....15
Installation Example: Class A Chimney Retrofit........16
Installation Example: Masonry Fireplace Hearth Stove....................... 17
Installation Example: Zero-Clearance (Metal) Fireplace Hearth Stove..1 8
Installation Example: Freestanding Masonry Chimney................19
Operation
Safety Notice....................................................20
Location of Controls ...........................................20
Starting the Heater for the First Time......................20
Loading Pellets..................................................21
The Two Modes of Operation ................................21
Operation (continued)
Manual Mode.....................................................22
Auto Mode........................................................23
Restrictor Adjustment.........................................24
Adjusting the Fan Speed......................................24
Start-Up Sequence.............................................25
"MANUAL AUGER" Button....................................25
"AUGER ON" Light..............................................25
"FAULT" Light....................................................25
Fault Codes (for qualified service personnel only).....25
Power Outages..................................................25
Using a Pellet/Corn Mix with This Heater .................26
Maintenance
Daily Maintenance (whenever using the stove).........27
Inspect the Burn ...........................................27
Make Sure Pellets are Not Piling Up...................27
Check Firepot for Clinkers...............................28
Cleaning the Firepot.......................................28
Door Opening ...............................................29
Bi-Weekly Maintenance (or every 10 bags of pellets).30
Flyash Removal ............................................30
Clean the Hopper...........................................30
Clean the Heat Exchange Tubes.......................30
Clean the Baffles...........................................31
Sweep Ash Into Ashpan..................................32
Check Ashpan, Dispose if necessary................33
Clean the Glass ............................................33
Yearly Maintenance (or every two tons)..................34
Clean the Vertical Exhaust Duct.......................34
Clean the Exhaust Blower ...............................36
Clean the Convection Blower ...........................37
Clean the Vent..............................................37
Adjusting the Door Hinge and Latch...................37
Check for Air Leaks Around the Door, Glass, and
Ashpan .......................................................37
Replacement Parts........................................38
Normal Operating Sounds
Normal Operating Sounds....................................39
Safety Label
Safety Label .....................................................40
Warranty
Warranty..........................................................41
Index
Index...............................................................42