Filter
Top Products
~_--
PART
NO.
CTVS24AA
GH1033
M-3212
M-3212
M-3212
AGH1059
AGH1059
EE8201
DESCRIPTION
FAN
TIMER
TRANSFORMER
BLOWER
RELAY
AlC
RELAY
BURNER
RELAY
24v
TERMINAL
STRIP
115v
TERMINAL
STRIP
BLOWER
MOTOR
TERMINAL
BLOCK
IGNITION
TRANSFORMER
----t-
.......
FUEL
PUMP
---t---.,
A
B
C
D
E
F
G
H
ITEM
LETIER
I.
Component Identification
PRESSURE
SWITCH
II. SAFETY
Please adhere to the following
warnings and cautions when
installing, adjusting, altering,
servicing, or operating the furnace.
1m
ortant
The
following Instruments
must
be
used
to
adjust
the burner
on
startup.
Failure to
use
the proper instruments
will
void
our
warranty
and
will
result in
an
unsatisfactory
instaUation.
BacharaCh
Electronic
Combustion
Analyzer
Bacharach
Smoke
Tester
(Or equivalent to
above)
Oil
Pressure
Gauge
! WARNING
TO PREVENT PERSONAL INJURY OR
DEATH DUE TO IMPROPER
INSTALLATION, ADJUSTMENT,
ALTERATION, SERVICE OR
MAINTENANCE, REFER TO THIS
MANUAL. FOR ADDITIONAL
ASSISTANCE OR INFORMATION,
CONSULT A QUALIFIED INSTALLER,
SERVICE AGENCY
OR
THE FUEL OIL
SUPPLIER.
___
--.
HIGH LIMIT
PRIMARY
OIL
CONTROL
t.---
BURNER
MOTOR
____
--
FUEL
FILTER
HEAD
+---+--__
FUEL
FILTER
CARTRIDGE
AUXILIARY UMIT
-----
MANUAL
RESET
----
CONDENSATE
COLLECTOR
----
BLOWER
DOOR
INTERLOCK
SWITCH
BLO'JER
SECTION
Figure 1
! WARNING
HIGH VOLTAGEI
TO AVOID PROPERTY DAMAGE,
PERSONAL INJURY
OR
DEATH DUE TO
ELECTRICAL SHOCK, THE FURNACE
MUST BE LOCATED TO PROTECT
THE
ELECTRICAL COMPONENTS FROM
WATER.
! WARNING
DO NOT UTILIZE THE HEATING UNIT
WITHOUT REASONABLE ROUTINE
INSPECTION, MAINTENANCE AND
SUPERVISION. IF THE UNIT IS IN A
BUILDING THAT IS OR WILL
BE
VACANT, CARE SHOULD
BE
TAKEN TO
ROUTINELY INSPECT, MAINTAIN AND
MONITOR THE UNIT. IN THE EVENT
THAT THE BUILDING
MAY
BE
EXPOSED
TO FREEZING TEMPERATURES AND
WILL
BE
VACANT, DRAIN
ALL
WATER-
BEARING PIPES, PROPERLY WINTERIZE
THE BUILDING AND TURN OFF
ALL
WATER SOURCES. IN THE EVENT THAT
THE BUILDING IS EXPOSED TO
FREEZING TEMERATURES AND IS
VACANT, ANY HYDRONIC COIL UNITS
SHOULD
ALSO
BE
DRAINED AND
AN
ALTERNATIVE HEAT SOURCE UTILIZED.
2