Filter
Top Products
Table of Contents 3
Travis Industries 4050525 100-01144
Introduction
Introduction......................................................2
Important Information .........................................2
Safety Precautions
Safety Precautions ............................................4
Specifications
Heating Specifications........................................6
Dimensions.......................................................6
Electrical Specifications......................................6
Fuel.................................................................6
EPA Compliance................................................6
Installation
Before you Begin ...............................................7
Packing List......................................................7
Installation Options............................................7
Planning the Installation......................................7
Minimum Fireplace Size.......................................7
Hopper Extension Set-Up ....................................8
Clearances.......................................................10
Mantel Requirements..........................................10
Hearth Requirements..........................................10
Facing Requirements..........................................10
Placing the Insert...............................................10
Venting the Pellet Stove......................................11
Maximum Venting Distance .............................11
Pellet Vent Type............................................11
Installing the Pellet Vent.................................11
Pellet Vent Termination...................................11
Mobile Home Requirements..................................12
Outside Air .......................................................12
Baffle Installation...............................................13
Restrictor Adjustment.........................................13
Surround Panel & Circuit Board Installation .............14
Installation into a Masonry Fireplace......................15
Installation into a Factory Built (Metal) Fireplace.......16
Operation
Safety Notice....................................................17
Location of Controls ...........................................17
Starting the Heater for the First Time......................17
Curing the Paint ............................................17
Priming the Auger..........................................17
Loading Pellets..................................................18
The Two Modes of Operation ................................18
Operation (continued)
Manual Mode.....................................................19
Auto Mode........................................................20
Restrictor Adjustment.........................................21
Adjusting the Fan Speed......................................21
Start-Up Sequence.............................................22
"AUGER ON" Light..............................................22
"MAINTENANCE REQUIRED" Light........................22
Power Outages..................................................23
Using a Pellet/Corn Mix with This Heater .................23
Maintenance
Daily Maintenance (whenever using the heater)........24
Inspect the Burn ...........................................24
Make Sure Pellets are not Piling Up...................24
Check Firepot for Clinkers...............................25
Cleaning the Firepot.......................................25
Opening the Door ..........................................26
Weekly Maintenance (or every 5 bags pellets) .........27
Flyash Removal ............................................27
Clean the Hopper...........................................27
Clean the Heat Exchange Tubes.......................27
Clean the Optional Plated Surfaces...................27
Check Baffles Ashbox and Ashpan, Dispose ......28
Clean the Glass ............................................28
Sweep Ash Into Ashpan..................................29
Yearly Maintenance (or every ton).........................30
Clean the Exhaust Duct..................................30
Clean the Exhaust Blower ...............................31
Clean the Vent..............................................31
Door Seal.....................................................32
Door Alignment .............................................32
Adjusting the Door Hinge and Latch...................33
Check for Air Leaks - Door, Glass and Ashpan ....34
Replacement Parts........................................34
Normal Operating Sounds
Normal Operating Sounds....................................35
Safety Label
Safety Label .....................................................36
Warranty
Warranty..........................................................37
Optional Equipment
Thermostat.......................................................38
ZC Kit ..............................................................39
Index
Index...............................................................40