Heatiator ECO-ADV-WS22 Manual

A SERVICE OF

next previous

36

Heatilator•ECO-ADV-WS22•7057-128C•August13,2010



Thimble Assembly:

12 in. (305mm) of

brick separation

between clay liner

and combustibles.

Fireclay liner 5/8 in.

(16mm) Minimum

or Equivalent.

Sill support

Header

Wood Stud 2 in.

(51mm)

Clearance from

chimney wall

Fireclay liner 5/8 in.

(16mm) Minimum

or Equivalent.



Foroptimalperformance,masonrychimneysusedtovent

thisapplianceshouldbe:

1.Linedwitha6inch(152mm)stainlesssteelliner.

 • Installationsintoaclayuewithoutastainlesssteel

linermayreducedrawwhichaffectsperformance,

causetheglasstodarkenandproduce excessive

creosote.

2.Itisrecommendedthatachimneywithalargerdiameter

than6inches(152mm)berelined.

 • Theoversizeduecancausepoorperformanceand

contributetotheaccumulationofcreosote.

3. Havethechimneycleanedbeforethestoveisinstalled

andoperated.

Thefollowingbulletslistthemorecriticalrequirementsfora

properlyconstructedchimney:

• The masonry wall of the chimney, if brick or modular

block,mustbeaminimumof4inches(102mm)nominal

thickness.

• A chimney ofrubble stone mustbe atleast 12 inches

(305mm)thick.

• Thechimneymusthaveareclayueliner(orequivalent)

withaminimumthicknessof5/8inch(16mm)andmust

beinstalledwithrefractorymortar.

 Anequivalentlinermustbealistedchimneylinersystem

orotherapprovedmaterial.



Sinceanoversizeduecontributestotheaccumulation

of creosote, the size of the ue should be checked to

determinethatitisnottoolargefortheappliance.



Thechimneyshouldalsobecheckedtoensureitmeets

the minimum standard of the National Fire Protection

Association(NFPA)Standard211.

• A chimney support package must be used when a

connectionismadethroughtheceilingtoafactorybuilt

chimney.

• Anapprovedthimbleandchimneysupportpackageare

  to provide safe clearances to

combustiblewallandceilingmaterial.

NOTICE: InCanada,theinstallationshallconformto

CAN/CSA-B365.

NOTICE: Check with your local building authorities

and/orconsulttheNationalFireProtectionAssociation

(NFPA211).