Support User Manuals

England's Stove Works 25PAH Gas Heater User Manual

Open as PDF

of 46

Page | 29

 YEARLYMAINTENANCE

ConvectionBlowerCleaning

Asalways,becertainthestoveiscoolandunpluggedbeforeservicinganycomponents

withintheunit.Sincetheconvectionblowerdoesnothandleanyby‐productsofcombustion,it

doesnotrequireseriouscleaningliketheexhaustblower.However,dustfromthehomeand

otherdebrisintheaircanaccumulateonthebladesoftheconvectionblower.Theconvection

blowerislocatedonthesideofthestoveoppositethecombustionblower,andanaccesspanel

onthestoveislocatedforeasyconvectionblowercleaning.Anydustthathasbuiltuponthe

fanbladescanusuallybe

easilyremovedwithavacuumorasoftpaintbrush.

CleaningPelletFinesfromtheHopperandAuger

Dependingonthetypeandqualityofpelletsburnedinthestove,someaccumulationof

pelletfinesanddustispossibleinthehopper.Thelowestpartoftheauger,nearthebackof

thestove,iswheremostfineswillaccumulate.Withthestoveoff,unplugged,completelycool

andwiththehopperempty,useautilityvacuumtoremovethefinesfromtheaugertube.If

thefinescannotberemovedfromthetopofthehopper:

 Removethebackpanelbyfirstremovingthethreescrewswhichsecuretheexhaust

outletcoverplate.Next,loosenthefourstovebackretainingscrewsandliftthebackup

andoffoftheunit.

 Locatetheaugermotorassemblyatthemiddlerearofthestove,andonceitisfound,

findthetwosetscrewsoneithersideofthecastironmountingcollar.

 Usinga3/16”allenwrench,loosenthesetscrewoneithersideoftheaugermounting

collar.

 Withautilityvacuuminhand,lettheaugerassemblyslideoutoftheaugertubejust

enoughsothatthevacuumcanbeusedtoremoveanyfinesfromthisarea.

 Reinstalltheaugerassemblyandtightenthetwosetscrews;reinstallthebackpanel

andtheexhaustoutletcoverplate,beingcertaintotightentheseven(7)retaining

screwsontherearofthestove.

CheckingGaskets



Anairtightsealatthedooropeningsandhopperlidopeningiscrucialtoproperstove

performance.Anyairleaksattheseareascannotonlycauseadirty,inefficientburnbutcan

alsoposeaserioussafetythreat.Becauseofthis,gasketsshouldalwaysbemaintainedingood

condition.Gasket

tightnesscanbecheckedusingthe“dollar‐bill”method:

 Placeadollarbillbetweenthegasketandthestovebody(atthelocationwherethe

gasketmeetsthestove).

 Tightenthelatchingmechanismdownandattempttopullthedollarbillout.Ifthe

dollarbillslidesin

andouteasily,thegasketneedstobereplaced.Thistestshouldbe

repeatedaroundtheentiregasketperimeter,asgasketswillsometimessealtightlyon

oneside,butwillbewornandsealpoorlyonanotherside.

previous next