Filter
Top Products
33
ALWAYS wear protective gloves and eye protection
when changing the battery or working around the
battery compartment.
To reduce the risk of FIRE or INJURY to persons:
• Disconnect ALL electric and battery power BEFORE
performing ANY service or maintenance.
• Use ONLY Chamberlain part #41A6357-1 for
replacement battery.
• DO NOT dispose of battery in fi re. Battery may
explode. Check with local codes for disposal
instructions.
Standby Power Unit (Optional)
OPERATING INSTRUCTIONS
1. Test the installed battery with the motor unit.
To test the battery, disconnect the motor unit power cord
from the electrical outlet.
• A solid orange LED indicates the battery is operating on
battery power.
• A fl ashing orange LED with beep indicates the unit is
operating on battery power and that the battery charge
is low.
• To test the battery is functioning properly, open and
close the garage door.
• Re-connect the motor unit power cord back into the
electrical outlet.
• Verify that the green LED is fl ashing on the BBU
(indicates that the battery is now charging).
• Test completed.
2. Charge the battery.
• Battery will take 24 to 48 hours to fully charge.
A fully charged battery supplies 12 Vdc to the motor
unit for one to two days of normal operation during an
electrical power outage. If the battery voltage drops too
low, the batteries will disconnect and the motor unit will no
longer operate under battery power.
After the electrical power has been restored, the battery
will recharge within 48 hours. Under normal usage
batteries will last 3 to 5 years.
To obtain maximum battery life and prevent damage,
disconnect the battery when motor unit is unplugged for
an extended period of time.
NOTE: Door operation may be limited until battery is fully
charged. The motor unit’s lights will not turn on during
battery mode.
NOTE: LED is most visible with worklight off.
GREEN LED:
All systems are normal.
• A solid LED light indicates the battery is fully charged.
• A fl ashing LED indicates the battery is being charged.
NOTE: Battery does not have to be fully charged to operate
the motor unit.
ORANGE LED:
The motor unit has lost power and is operating off of the
battery.
• A solid LED with beep, sounding approximately every
2 seconds, indicates the motor unit is activating the
door and is operating off of the battery.
• A fl ashing LED with beep, sounding every 30 seconds,
indicates battery is low.
• Once the power is restored the battery will recharge.
This is indicated by a fl ashing green LED.
RED LED:
• If a red LED remains on when the power is restored,
and is accompanied by a beep sounding every
30 seconds, replace the battery.
• To obtain maximum battery life and prevent damage,
also disconnect the battery if you unplug the motor unit
while on vacation or any other extended period of time.
Battery
Status
LED