Weil-McLain BCP-8X Boiler User Manual


  Open as PDF
of 28
 
17
%&36,QVWDOODWLRQDQG2SHUDWLRQ0DQXDO
23(5$7,1*6(77,1*6
Can be accessed by holding down the Menu button for over three seconds.
352*5$0&+$1*(6(77,1*6
To be able to change the BCP-8S settings the Program/Run Switch must be set to Program.
The switch is located under the Enclosure Wiring Cover for security. The Enclosure Wiring
Cover can be securely closed using a padlock.
PROGRAM RUN
6($621
:LQWHU6XPPHU 'HIDXOW:LQWHU
Button: MENU/Season
 7KH%&36ZLOOWXUQDOOERLOHUUHOD\VRIIZKHQLWLVLQ6XPPHUVHWWLQJ7KH0HVVDJH
'LVSOD\/LQHZLOOUHDGSummer to show status.
 :KHQLQ:LQWHUWKH%&36ZLOODFWLYDWHWKH6\VWHPUHOD\ZKHQHYHUWKH2XWGRRU
temperature falls to or below the Outdoor Cutoff setting. In addition, it will begin
heating whenever the System pressure falls below the Set Point. The Message Display
/LQHZLOOQRWGLVSOD\DQ\VHDVRQLQIRUPDWLRQ
 :KHQWKHVHDVRQLVRYHULWLVDJRRGSUDFWLFHWRVZLWFKWKH%&366HDVRQVHWWLQJWR
Summer to turn off all heating instead of turning off the control. This will preserve the
battery life.
$/(57
DO NOT turn power off to the
BCP-8S when in off-season. If
you do so, the battery will run
down and have to be replaced.
Instead, switch to Summer.
---- SEASON ---
Winter
Summer
BACK SAVE
6(732,17127$'-867$%/(,1(0602'(
6HHSUHVVXUH7UDQVGXFHU'HIDXOW6HWWLQJVDQG5DQJHV7DEOH
Button: MENU/Set Point ,Q6HW3RLQWRU(06P$
 7KH6HWSRLQWLVWKHSUHVVXUHYDOXHWKH%&36ZLOOXVHWRFRQWUROWKHV\VWHP
 7KH%&36ZLOODGGVXEWUDFWRUKROGWKHVWDJHVRIWKHKHDWLQJERLOHUVWRPDLQWDLQWKH
system pressure around the Set point.
----- SET POINT -----
12.0psi
[ ]
BACK SAVE
 7KHV\VWHPFDQEHH[SHFWHGWRRVFLOODWHDURXQGWKHVHWSRLQW7KHDPRXQWRIRVFLOODWLRQGHSHQGVRQWKH6\VWHP6HWWLQJVDQG
Stage Settings.
 ,IDQ2XWGRRU6HQVRUZDVFRQQHFWHGSUHVVLQJWKH6$9(EXWWRQZLOOVZLWFKWRWKH2XWGRRU&XWRIIVHWWLQJRSWLRQ
 ,IWKH(060RGHZDV(QDEOHGWKH6HW3RLQWZLOOEHVHWE\WKH(06%06V\VWHPDQGZLOOEHDYDLODEOHDVUHDGRQO\
 $Q\YDOXHEHORZWKHP$RUDERYHP$ZLOOLQGLFDWHDShutdown by EMSPHVVDJHRQWKH0HVVDJH/LQH
287'225&872))7(03(5$785(
$GMXVWDEOH2IIº)º&º)º&2Q 'HIDXOW)&
Button: MENU/Set Point/Outdoor Cutoff LQ6HW3RLQW
 ,Q6HW3RLQWPRGHLIWKHRXWGRRUVHQVRULVLQVWDOOHGWKH2XWGRRU&XWRIIVFUHHQZLOO
automatically appear after the pressure Set Point has been selected.
-- OUTDOOR CUTOFF -
60 F
[ ]
BACK SAVE
 :KHQWKHRXWGRRUWHPSHUDWXUHIDOOVWRWKHDGMXVWDEOH2XWGRRU&XWRIIWHPSHUDWXUHWKH%&36ZLOOFRQWURODQGVHTXHQFHWKH
boiler stages to hold the set point.
 :KHQWKHRXWGRRUWHPSHUDWXUHULVHVWRWKH2XWGRRU&XWRIISOXVD)GLIIHUHQWLDOWKH%&36ZLOOWXUQDOOERLOHUVRII7KH
6\VWHPDQG&RPE$LUUHOD\VWKDWZHUHHQHUJL]HGZLOOUHPDLQHQHUJL]HGIRUWKH5XQ2QGHOD\WKHQGHHQHUJL]H
 7KH2XWGRRU&XWRIIFDQEHVHWWR21RU2)),QWKH21SRVLWLRQWKH6\VWHP5HOD\ZLOOUXQUHJDUGOHVVRIWKH2XWGRRU
temperature and the burner stages will be active to hold the set point.
 ,QWKH2))SRVLWLRQWKH6\VWHP5HOD\ZLOODOZD\VEHRIIDQGDOOVWDJHVZLOOEHRIIDVZHOO
6<67(06(77,1*6
Hold Button: MENU/<System Settings>
7KH6\VWHP6HWWLQJVPHQXSURYLGHVDFFHVVWRDGMXVWLQJDQG¿QHWXQLQJWKHKHDWLQJV\VWHP
for enhanced comfort and better fuel savings. The BCP-8S behaves differently based on the
selected Control Modes (see Startup Settings on page 14).
- SYSTEM SETTINGS -
<Stage Settings>
<Setback Schedule>
Setback 0.0Psi
Run-On 2min
System ExerciseOff
BACK SELECT
 previous next