Filter
Top Products
US
G B
G B
G B
G B
G B
When warranty repair is needed, the engine must be brought to an
authorized service dealer or warranty station’s place of business during
normal business hours. In all cases, a reasonable time, not to exceed
30 days, must be allowed for the warranty repair to be completed after
the engine is received by the authorized service dealer or warranty station.
G. MAINTE NANC E, R E PLACE ME NT AND
R EP AIR OF E MIS SION-R E LATE D PAR TS
Only warranted engine replacement parts approved by FUJI should
be used in the performance of any warranty maintenance or repairs
on emission-related parts. If other than authorized parts are used for
maintenance, replacement or repair of components affecting emission
control, you should assure yourself that such parts are warranted by
their manufacturer to be equivalent to authorized parts in performance
and durability. FUJI ,however, assumes no liability under this warranty
with respect to parts other than authorized parts. The use of non-
authorized replacement parts does not invalidate the warranty on
other components unless the non-authorized parts cause damage to
warranted parts.
H. PAR TS COVER E D UNDE R THE CAL IFOR NIA E MIS SIONS
WAR R ANTY
(1) Fuel Metering S ystem
(i) Carburetor and internal parts
(ii) Air cleaner plate (including choke system)
(iii) Air cleaner cover
(iv) Air cleaner element
(2) Ignition S ystem
(i) S park plug
(ii) Flywheel magneto
(iii) Ignition coil
(3) Miscellaneous Items Used in Above S ystems
(i) Hoses and sealing gaskets, bolts, connectors, and assemblies.
I. MAINTENANCE STATE ME NTS
It is your responsibility to have all scheduled inspection and maintenance services performed at the times recommended in the 2000 and later
Owner's Manual and to retain proof that inspection and maintenance services are performed at the times when recommended. FUJI will not
deny a warranty claim solely because you have no record of maintenance; however, FUJI may deny a warranty claim if your failure to perform
required maintenance resulted in the failure of warranted part. The proof which you maintain should be given to each subsequent owner of the
engine. You are responsible for performing the scheduled maintenance described below based on the procedures specified in the 2004 and
later Owner's Manual. The scheduled maintenance below is based on a normal engine operating schedule.
PR OCEDUR E INTE RVAL
1) Clean engine and check bolts and nuts. R etighten if necessary. : Every 8 hours (daily)
2) Check and refill engine oil (4 stroke) : Every 8 hours (refill daily up to upper limit)
3) Change engine oil (4 stroke) : Initial 20 hours and every 100 hours afterward
4) Check clogging of cooling air passage and cylinder fins. : Every 8 hours (daily)
Note: More frequent maintenance may be necessary under dusty, dirty or severe conditions.
(v) Fuel Filter
R emove and clean if necessary.
12) Replace packings and gaskets with new ones.
11) Overhaul engine.
10) Replace fule lines.
9) Adjust valve clearance, if applicable (4 stroke)
8) Check fuel filter. If clogged, replace with new one.
7) Check muffler exhaust outlet (or port). Clean if necessary.
6) Check spark plug. Clean and adjust if necessary.
5) Clean air cleaner
: Every reassembling
: Every 200 hours
: Every 8 hours (daily)
: Every 8 hours (daily)
: Every 50 hours (monthly)
: Every 50 hours (monthly)
: Every 200 hours
: Every 200 hours