Filter
Top Products
Xtremely Small Footprint
TOP VIEW
FRONT VIEW REAR VIEW
PROUDLY MADE IN AMERICA
ULTRA HIGH EFFICIENCY
50
B
31-1/8
12-7/16
Y
2-7/8
E
L
F
M
14-7/16
D
P
ØK - FLUE CONNECTION
2-1/2” NPT WATER INLET
2-1/2” NPT WATER OUTLET
ØN - COMBUSTION AIR
OPTIONAL
R
G- GAS CONNECTION
POWER CONNECTIONS
CONDENSATE DRAIN
CONNECTION
25
LOW VOLTAGE
CONDUIT
CONNECTION
(BY OTHERS)
FLUE CONNECTION
*For propane gas, all models are 1-1/4” NPT.
†
Amp load does not include primary heater pump; a separate 120 VAC electrical connection must be supplied for the primary pump.
CLEARANCES
Floor* 0 N/A
Rear 12 36
Right Side 1 24
Left Side 11
Front 24 24
Top Indoor 0 10
Outdoor Unobstructed Unobstructed
Vent Stack Indoor 1 N/A
Vent Cap Outdoor 12 12
From Combustible
Surfaces (min.)
For Service
(Minimum)
* Do not install on carpeting Note: Local codes may require increased clearances
Heater
Side
Model
Pool Heater
Output Efficiency
MBTUH
Input
MBTUH
1005 999 969 97%
1505 1500 1455 97%
2005 1999 1939 97%
PHYSICAL DATA
1005 55-1/8 45 47-1/8 36-1/2 1-1/4 6 40-1/16 11-1/2 6 47-1/8 8-1/16 6-1/16 1065 12 10
1505 67-1/8 57 59-1/16 38-1/2 1-1/4 8 52-1/16 12-5/8 8 59-1/8 8-3/16 6-1/16 1234 12 14
2005 81-1/8 71 71-3/16 38-1/2 2864-1/16 12-5/8 8 73-1/8 8-3/16 6-1/4 1461 18 17
5
Total footprint: Less than 11 ft
2
!
Xtremely Small Footprint
Salt Water Chlorination
The XTherm can be used with pools that are sanitized via Salt Water Chlorination;
up to 3000 PPM.
As with all Raypak heaters, please feel free to contact your local Raypak representative
or our Applications Department for assistance with planning your next installation.
Model
Dimensions (inches)
B
Ht.
Pump
Amps
†
Weight
(lbs.)
D E F
G
*
NPT
K
Flue Ø
L M
N
C/A Ø
P R Y
H-Models Hydronic
Boiler
Amps
6200.12-E_XTherm Brochure 8 page 3/29/11 10:59 AM Page 6