PVI Industries PV 413A Water Heater User Manual


 
PV 413 8/05 817-335-9531 800-433-5654 FAX 800-880-2019 www.pvi.com
Model Number: Serial Number:
VENTING and COMBUSTION AIR
Vent Material: (CPVC – Water Heaters Only; AL29-4C Stainless Steel – Boilers or Water Heaters)
Vent Diameter: inches; Vent Length: feet Vent Type: Through-the-roof Through Sidewall
Does vent have condensate drain? Yes No Does vent have elbows? Yes; Qty No
Does vent contain any of these devices? Power Vent Draft Inducer Draft Regulator Flue Damper
Combustion air louvers or openings? Yes; Qty: Size: No Interlocked? Yes No
Have direct-ducted combustion air? Yes; duct diameter inches, length feet. No
Duct Material: Does duct have elbows? Yes; Qty No
GAS SUPPLY
Type of Gas: Natural LP Inlet Static Gas Pressure: “W.C. (14”W.C. maximum)
Gas Supply Pipe Size: Inlet Flow Gas Pressure: “W.C. (see data label)
Combination Gas Pressure Switch Setting: High “W.C. Low “W.C.
COMBUSTION ANALYSIS
Boilers
Heaters
1
st
Stage 2
nd
Stage
Pilot Gas Pressure
Manifold Gas Pressure
Carbon Dioxide CO
2
(8-9%)
Oxygen O
2
(5-7%)
Carbon Monoxide CO (less than 200 ppm)
Nitrogen Oxide NO
X
(if available)
Vent Pressure (+.25” to + 2.0” W.C.)
Gross Vent Temperature (maximum 230°F)
less Room Temperature °F
= Net Vent Temperature °F
Important: You must submit the original copy of the completed form to your PVI representative before the
warranty will become effective on this product. Contact Customer Service for assistance at 1-800-433-5654.
Service Company Name: Phone:
Service Co. Address:
Start-up Performed By:
Date:
Customer:
Phone No.: Date:
Page 2 of 2