Filter
Top Products
20"
26"
16"
8"
52 1/4"
20"
19 1/4"
44"
4 3/4"
NOTE: DASHED LINES SHOW
STRAIGHT UP AND THROUGH
THE WALL INSTALLATION
8"
32 1/4"
16"
FLOOR PROTECTOR
(TOP VIEW)
SIDEWALL
NON-COMBUSTIBLE
CONSTRUCTION IN
ACCORDANCE WITH
NFPA 211
LOCATING THE HEATER
AS A LOCATION IS SELECTED,
KEEP THE FOLLOWING IN MIND:
1. The chimney connection should be as
possible. The heater must have its own chim-
ney. Do not connect this unit to a chimney flue,
serving another appliance. If there is no chim-
ney near where you wish to place the heater,
you can use a UL 103HT Residential Type and
Building Heating Appliance Chimney (Fig. 5
&6).
2. Place the heater on solid masonry or solid
concrete. When the heater is used on a com-
bustible floor protector of one layer of 3/8"
millboard having a thermal conductivity of
K=0.84 BTU in./ft. 2 hr. Deg. F with 28-gauge
sheet metal or a UL Listed floor protector. Have
the floor protector extend 16" beyond the door
side of the heater and under the connector pipe
in the back.
3. Check Figures 2, 3, and 4. Be sure you have
the clearances shown from the heater and the
connector pipe to combustible surfaces. If you
have a solid brick or stone wall behind your
heater, you can place the heater as close as
you wish to the wall. If the wall is only faced with
brick or stone, treat it as a combustible wall.
NOTE: BEFORE FIRING
HEATER
Slide firebricks toward the rear
so no gaps remain between
them.
CAUTION:
Keep furnishings and other
combustible materials away
from the heater.
4
REPAIR PARTS LIST - MODEL 2927 (SEE PAGE 18)
AUTOMATIC COAL BURNING CIRCULATOR
17
Fig. 3
Fig. 2
Fig. 4
Key No. Description Qty. Part No.
1 Shaker 1 40045
2 Ash Pan 1 68574
3 Base 1 67859
4 Draft Damper Hinge Pin 1 17200
5 Draft Damper Frame 1 40075
6 Draft Control Plate 1 68583
7 Clip 2 83818
8 Glass Brass Trim (LH/RH) 2 89382
9 Glass Brass Trim (TOP/BOTTOM) 2 89381
10 Glass Frame 1 68452
11 Glass Gasket 66" 88047
12 Glass (20 1/2"x12 1/2") 1 89409
13 Front Half Brick 1 23782
14 Front Coal Grate 1 40283
15 Flue Collar 1 40287
16 Fire Box Weldment 1 68655
17 Firebrick Retainer 1 40132
18 Firebrick 7 89066
19 Door Hinge Pin 1 83114
20 Feed Door 1 68605
21 Feed Door Rope Gasket 44" 88033
22 Machine Screw (1/4-20x1) 1 53227
23 Draft Wheel 1 40056
24 Door Handle 2 40091
25 Flat Washer 1 83045
26 Hex Nut (1/4-20) 2 83250
27 Latch 1 22108
28 Ash Door Rope Gasket 29" 88033
29 Ash Door 1 67781
30 Hex Nut (1/4-20) 1 83250
31 Front Liner 1 40100
32 Coal Grate Frame 1 40102
33 Coal Grate 1 40101
34 Rear Half Brick 1 23785
35 Back Brick Retainer 1 23145
36 Flue Baffle 1 23249
37 Flue Collar Gasket 1 88032
38 Air Wash Deflector 1 23547
* Grate Support 2 22536
* Corner Key (Brass Trim) 10 89419
* Blank Key (Brass Trim) 10 89420
39 Wood Handle (Optional) 2 89523
40 Door Hinge Pin 1 23441
41 Two Step Latch 1 22434
42 Latch Spacer 1 21467
43 Smoke Curtain 1 22090
* Smoke Curtain Bracket 2 22171
* NOT SHOWN