Filter
Top Products
Turn"OFF" the gas supply to the water heater.
WARNING
If the main gas line shutoff serving all
gas appliancesis used, also shut "6FF"
{he _[asat each appliance. Leave all gas
appliances shut _'OFF" until the water
heater installation
Q Turn "OFF" the water to the water
heater. Some installations require
that the water be turned off to the
entire house.
®
Check again to make sure the gas
supply is "OFF" to the water heater.
Then disconnect the gas supply con-
nection from the gas control valve.
Q Attach a hose to the water heater
drain valve and put the other end in
a floor drain or outdoors. Open the
water heater drain valve. Open a
nearby hot water faucet which will
relievepressure in the water heater
and speed draining.
®
®
®
Q Disconnect the vent from the draft hood
pipe
where they connect to the water heater. In most
installations the vent pipe can be lifted off after
any screw or other attached devices are removed.
Dispose of the draft hood. The new water heater
has the draft hood which must be used for proper
operation.
G a. lf you have copper piping to the
water heater, the two copper water
pipes can be cut with a hacksaw
approximately four inches away
from where they connect to the
water heater. This will avoid cutting
off the pipes too short. Additional
cuts can be made later if necessary.
Disconnect the temperature-pres-
O sure relief valve drain line. When
the water heater is drained, discon-
nect the hose from the drain valve.
Close the drain valve. The water
heater is now completely discon-
nected and ready to be removed.
If you have galvanized pipe to the
water heater, loosen the two galva-
nized pipes with a pipe wrench at
the union in each line. Also dis-
connect the piping remaining to
the water heater. These pieces
should be saved since they may be
needed when reconnecting the
new water heater. Disconnect the
temperature-pressure relief valve
drain line. When the water heater
is drained, disconnect the hose
from the drain valve. Close the
drain valve. The water heater is
now completely disconnected and
ready to be removed.
iTh WARNING
e water passin£ out of the drain valve may be
extremely hot 1_oavoid being scalded, make
sure all connec'tionsare tight and that the water
ow is directed away from any person.
CAUTION
Mineral buildup or ._edlmentmay haye accumulated
in the old water heater. This causes the water heater
to be much heavier than normal and this residue, if
spilled out, could cause stalnlng.