Filter
Top Products
2
Up to 99% part load!
Xtreme Outdoor
Performance
XFyreT Condensing Modulating Boiler
- The Green Choice
Raypak’s new XFyreT is a natural extension of our successful
XThermT modulating vertical boiler line
(1,1.5, 2 Million BTUH). Raypak
offers new features not found in other mod-con style boilers and
combines these desirable features into one complete boiler package.
XFyre is the
only condensing boiler
(300 to 850MBTUH)
with CSA out-
door certification. Utilizing cabinet and control technology already
proven in over 250,000 Raypak pool heaters, the XFyre comes to
market as a seasoned veteran of outdoor environments. Mechanical
engineers, architects and building owners now have extreme instal-
lation flexibility, high efficiency, space saving footprint, zero side
clearance, direct vent capability, PVC venting and full service access.
Installers enjoy ease-of-commissioning, reliability, serviceability and
long-term performance. Small space, no longer a problem. Raypak’s
vertical water connections allow the units to be installed side by
side, further reducing the footprint on multi-boiler installations. Our
compact design makes it possible to install 6.8 million BTUH in
under 67 ft
2
of floor space, plus front and rear clearance. Tie them all
together with the built in Cascade Control and you have a boiler
system with a 40:1 turndown that operates at 94% thermal efficien-
cy! This is an Xtreme green retrofit system.
XFyre Combustion System
Modulation is nothing new to Raypak. We have been honing our gas
modulation experience for over 50 years. The Raypak XFyre will pre-
cisely track the heating load with its built-in Computer Control
System and built-in outdoor reset function, eliminating costly over-
shooting. Utilizing the latest European technology for the combus-
tion-components, the optimum fuel-air ratio is maintained through-
out the entire range of the load-tracking operation. Our 5:1 turn-
down ensures efficiency is maintained throughout the firing rate and
actually increases during part load, right when you want it! The
XFyre automatically self-tunes to accommodate the widest range of
gas supply pressures. The high quality integrated blower-gas valve is
self-correcting and allows smooth operation with fluctuating gas
supply pressures. The Raypak XFyre is cutting edge technology with
atmospheric simplicity
.
Vent Flexibility
Category IV -CSA-certified 94% efficiency at
full fire for hydronic boilers and 95% for domes-
tic water heaters
(Up to 99% at part load!)
When the job requires high efficiency, XFyre
meets your needs. Combined vent and combus-
tion air duct length of up to 200 equivalent feet.
Vent your project in PVC, CPVC or Stainless.
XFyre is
CSA certified for all three. The XFyre ships PVC ready with
no extras to purchase!
Key Features
• 5 models from 300,000 to 850,000 BTUH
• 94% thermal efficiency hydronic and 95% water heaters
• AB-1953 Low Lead Verified
• All models CSA indoor/outdoor certified
• Small footprint, less than 9-1/2 square feet
• Top side water connections - allows side by side installation
• All models are equipped with 316L welded stainless steel heat
exchanger and copper plumbing. ASME Section IV constructed
and stamped. National Board registered.
• Multiple pump outputs - Boiler Pump, System Pump,
Indirect Pump
• Dual flame sensing - Flame sensor and spark ignition rod
• Modulating gas valve and burner, up to 5:1 turndown
• Meets all current Low NOx regulations, including the new
(<20ppm) SCAQMD revisions
• Whisper quiet operation
• On-board diagnostic center, real English, no codes.
• 0-10 VDC BMS Interface (setpoint or direct drive)
• Built-in cascade function for up to 8 boilers
• Built-in outdoor reset functionality
• Complete cabinet protects all controls and wiring
• Tough rust-resistant powder coat finish
• Easy to service - removable air filter
• PVC-CPVC-Stainless vent certified
• Suitable for altitudes up to 10,000 ft. (derate may apply)
Options
• Outdoor air sensor (B-32)
• Indirect sensor
• TruSealT direct vent kit (D-21 factory installed, D-22 Loose)
• PC interface cable
• Condensate neutralizer (Z-12)