Filter
Top Products
PV 19 8/05 817-335-9531 ● 800-433-5654 ● FAX 800-880-2019 ● www.pvi.com Page 2 of 3
START-UP REPORT
STEAM/WATER - TO - WATER HEATERS
QUICKDRAW
®
- CSX - ISX
Warning: Startup must be performed by a qualified service installer, service agency or the gas supplier.
Model Number:
Serial Number:
Job Name:
Address:
GENERAL INFORMATION
Restart? Yes No Installation is: New Replacement/Renovation Indoor Outdoor
Primary operating voltage: VAC Voltage from neutral to earth ground: (should be zero)
Thermostat Set Points: Hi-Limit °F Upper Operating: °F Operating °F
Operating (optional): °F Operating (optional): °F
Cold Water Inlet Temperature: °F Hot Water Outlet Temperature: °F
T & P Relief Valve(s) plumbed to a suitable drain? Yes No
WATER HEATER INSTALLATION
Type of piping connected to heater: Copper Brass Galvanized
Is there a check valve in the supply water piping? Yes No
Is there a water softener on the cold water supply? Yes No Operational? Yes No
Is there a mixing valve on the hot water supply? If yes; temperature setting: °F No
Is there expansion relief in the cold water supply? If yes, what type: tank valve No
Is there a recirculation loop? Yes Circulating pump horsepower: No
Is there a floor drain in the room? Yes No
STEAM SYSTEM
Static Steam Pressure: PSI Flow Steam Pressure: PSI Operating Steam Pressure: PSI
Is steam supplied from utility company or installed boilers?
Is there a condensate trap in the steam supply main? Yes No
Is there lift in the condensate return line? (Before receiver tank) Yes No Lift in feet: FT
Is there a steam strainer ahead of the appliance steam valve? Yes No Size: in. Mesh:
Is there a steam trap ahead of the appliance steam valve? Yes No
Is there a steam trap in the appliance condensate line? Yes No
Does steam flow stop completely when steam valve is de-energized? Yes No
Model Number:
Serial Number: