Filter
Top Products
Across the upper edge of the front unloading unit is a
“Warning Push For Emergency Stop” pushbar. By
pushing on this bar during front unloading operation
only, the forage box will shut down in an emergency.
Emergency stop trip cables connected to the “Emer
-
gency Stop” pushbar extend along both sides and down
the front of the forage box. Pulling on these trip cables
will also shut down the front unloading unit
of the forage
box in an emergency.
Note: The emergency stop mechanism DOES NOT
STOP the PTO drive shaft, northe rear unloadingop
-
eration of the forage box.
WARNING: THE EMERGENCY STOP MECHA-
NISM STOPS ONLY
THE FRONT UNLOADING UNIT
FROM OPERATING AND NOT
THE REAR UNLOADING
OPERATION OF THE FORAGE BOX!
WARNING: DO NOT RESET THE EMER
-
GENCY STOP MECHANISM UNTIL ALL PEOPLE,
TOOLS AND OTHER OBJECTS ARE WELL CLEAR
OF THE FORAGE BOX. FAILURE TO HEED MAY RE
-
SULT IN SERIOUS PERSONAL INJURY OR DEATH.
To reset the emergency stop mechanism, fully en-
gage the INDEPENDENT OUTFEED CLUTCH con
-
trol lever into the “RUN” position.
Check frequently to be assured that the emergency
stop mechanism is in proper operating condition.
Slowly engage the tractor PTO and operate the for
-
age box at an idle speed to ensure it is operating
properly. Push the emergency stop bar across the
upper edge of the front unloading unit, to ensure that
the forage box can be shut down in an emergency.
Reset the emergency stop and recheck using the
emergency stop trip cables at various locations to en
-
sure that the forage box can be shut down in an emer
-
gency. Periodically repeat emergency stop
inspections during the operating season and at all
times keep excessive slack out of the emergency
stop trip cables.
3200 & 4200 Series --8–
WARNING:
WARNING: IF FOR ANY REASON THE EMERGENCY STOP MECHANISM DOES NOT FUNCTION PROPERLY,
DO NOT USE THE MACHINE UNTIL IT IS REPAIRED. FAILURE TO HEED MAY RESULT IN SERIOUS PERSONAL IN
-
JURY OR DEATH.
EMERGENCY STOP
PUSH BAR
EMERGENCY STOP TRIP LOCATIONS
EMERGENCY STOP
TRIP CABLE AT
FRONT
EMERGENCY STOP TRIP
CABLES EXTENDING
ALONG BOTH SIDES
INDEPENDENT OUTFEED CLUTCH CONTROL
LEVER
OPERATION OF THE EMERGENCY STOP
RESETTING THE EMERGENCY STOP