Coleman 5459 Stove User Manual


  Open as PDF
of 2
 
To Turn OffTo Light To Clean
Things You Should
Know
For products purchased
in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 1-316-832-8707
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
1-800-387-6161
1. It is unsafe and illegal in some places
to store or use propane cylinders of
greater than 1.14 kg (2.5 lbs.) water
capacity (approximately 1 lb. propane)
in occupied enclosures.
2. The usual storage areas for camping
and picnic equipment are the
basement, attic, or garage. To avoid
the accumulation of dust, cobwebs,
etc., that is common in these storage
areas, place your stove in a plastic bag
and seal it with a rubber band.
3. For repair service call one of the
numbers listed on the front cover
for location of your nearest Coleman
Service Center. If product must be
mailed to Service Center, attach to the
product a tag that includes your name,
address, daytime telephone number
and a description of problem. DO
NOT send propane cylinder. Carefully
package the product and send
either by courier or insured mail with
shipping and insurance prepaid to:
4. If not completely satised with the
performance of this product, please
call one of the numbers listed on the
cover of this manual.
www.coleman.com
To Store
EXPLOSION - FIRE HAZARD
• Never store propane near high heat,
open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed
120 ºF (49 °C).
• The cylinder must be disconnected
when the stove is in storage.
DANGER
Parts List
BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
WARNING
Standard Ignition Stoves
Set on sturdy, at surface. For outdoor
use only.
Leak Check
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until
connection has been leak tested and
does not leak.
WARNING
EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can
accumulate in low places. If you smell
gas, leave the area immediately.
• Always attach or detach propane source
outdoors; never while stove is lighted,
near flame, pilot lights, other ignition
sources or while stove is hot to touch.
• This stove is very hot during use and
can ignite flammables too close to the
burners. Keep flammables at least 12
inches from the sides and 48 inches from
the top of the stove. Keep gasoline and
other flammable liquids and vapors well
away from stove.
• The stove must not be exposed to
flammable vapors or liquids
during lighting.
DANGER
Hold lighted match near burner and
open burner valve. (Fig. 9 and 10)
English - 5 English - 6
English - 7 English - 8
If you smell gas:
1. Do not attempt to
light appliance.
2. Extinguish any
open flame.
3. Disconnect from
fuel supply.
FOR YOUR
SAFETY
Do not store or
use gasoline or
other liquids with
flammable vapors in
the vicinity of this or
any other appliance.
FOR YOUR
SAFETY
DANGER indicates an imminently
hazardous situation which, if not
avoided, will result in death or
serious injury.
DANGER
WARNING indicates a potentially
hazardous situation which, if not
avoided, could result in death or
serious injury.
WARNING
CAUTION indicates a potentially
hazardous situation which, if
not avoided, may result in minor
or moderate personal injury, or
property damage.
CAUTION
CARBON MONOXIDE
HAZARD
•This appliance can
produce carbon
monoxide which has
no odor.
•Using it in an
enclosed space can
kill you.
•Never use this
appliance in an
enclosed space
such as a camper,
tent, car or home.
DANGER
This manual contains important
information about the assembly, operation
and maintenance of this outdoor propane
appliance. General safety information is
presented on this page and is also located
throughout these instructions. Particular
attention should be paid to information
accompanied by the safety alert symbol
“
DANGER”, “ WARNING”,
“
CAUTION”.
Keep this manual for future reference and
to educate new users of this product. This
manual should be read in conjunction with
the labeling on the product.
Safety precautions are essential
when any mechanical or propane fueled
equipment is involved. These precautions
are necessary when using, storing, and
servicing. Using this equipment with the
respect and caution demanded will reduce
the possibilities of personal injury or
property damage.
The following symbols shown
below are used extensively throughout
these instructions. Always heed these
precautions, as they are essential when
using any mechanical or propane
fueled equipment.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and by products
of combustion of this fuel, contain
chemicals known to the state of
California to cause cancer, birth defects,
or other reproductive harm.
• Failure to comply with the
precautions and instructions
provided with these stoves can
result in death, serious bodily
injury and property loss or damage
from hazards of fire, explosion,
burn, asphyxiation, and/or carbon
monoxide poisoning.
• Only persons who can understand
and follow the instructions should
use or service these stoves.
• If you need assistance or information
such as an instruction manual
or labels, contact The Coleman
Company, Inc.
DANGER
• This product is fueled by propane
gas. Propane gas is invisible,
odorless, and flammable. An odorant
is normally added to help detect
leaks and can be described as a
“rotten egg” smell. The odorant can
fade over time so leaking gas is not
always detectable by smell alone.
• Propane gas is heavier than air and
leaking propane will sink to the
lowest level possible. It can ignite by
ignition sources including matches,
lighters, sparks or open flames of
any kind many feet away from the
original leak. Use only propane gas
set up for vapor withdrawal.
• Propane gas should be stored
or used in compliance with local
ordinances and codes or with ANSI/
NFPA 58. Turn off propane when not
in use.
WARNING
SERVICE SAFETY
• Keep all connections and fittings
clean. Inspect propane cylinder
and stove propane connections for
damage before attaching.
• During set up, check all connections
and fittings for leaks using soapy
water. Never use a flame. Bubbles
indicate a leak. Check that the
connection is not cross-threaded
and that it is tight. Perform another
leak check. If there is still a leak,
remove the cylinder and contact
Coleman for service or repairs.
• Use as a cooking appliance only.
Never alter in any way or use with
any device or part not expressly
approved by Coleman.
• Clean stove frequently to avoid
grease accumulation and possible
grease fires.
CAUTION
BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
WARNING
EXPLOSION - FIRE HAZARD
• Never store propane near high heat,
open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed
120 ºF (49 °C).
• Propane is heavier than air and
can accumulate in low places.
If you smell gas, leave the area
immediately.
• Never install or remove propane
tank while outdoor stove is lighted,
near flame, pilot lights, other ignition
sources or while outdoor stove is hot
to touch.
• During lighting and operation, this
product can be a source of ignition.
Never use the stove in spaces that
contain or may contain volatile or
airborne combustibles, or products
such as gasoline, solvents, paint
thinner, dust particles or
unknown chemicals.
• Minimum clearances from
combustible materials: 12 inches
from the sides and 48 inches from
the top.
• Provide adequate clearances
around air openings into the
combustion chamber.
DANGER
CARBON MONOXIDE HAZARD
• This stove is a combustion
appliance. All combustion appliances
produce carbon monoxide (CO)
during the combustion process.
This product is designed to produce
extremely minute, non-hazardous
amounts of CO if used and
maintained in accordance with all
warnings and instructions. Do not
block air flow into or out of the stove.
• Carbon Monoxide (CO) poisoning
produces flu-like symptoms, watery
eyes, headaches, dizziness, fatigue
and possibly death. You can’t see it
and you can’t smell it. It’s an invisible
killer. If these symptoms are present
during operation of this product get
fresh air immediately!
• For outdoor use only.
• Never use inside house, camper,
tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and
produces carbon monoxide
(CO). Do not use in unventilated
or enclosed areas to avoid
endangering your life.
DANGER
CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper,
tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and produces
carbon monoxide (CO). Do not use
in unventilated or enclosed areas to
avoid endangering your life.
DANGER
Technical
Characteristics
To Set Up
Not for home or
recreational vehicle use.
We cannot foresee every use which
may be made of our products. Check
with your local fire safety authority
if you have questions about use.
Other standards govern the use of fuel
gases and heat producing products
for specific uses. Your local authorities
can advise you about these.
• Never refill disposable cylinders.
• Use the preset regulator that came
with the stove. Do not attempt
to adjust.
• Use only Coleman
®
accessories or
parts. During stove set-up, check all
fittings for leaks using soapy water.
Never use a flame.
WARNING
NOTE: Use Coleman
®
16.4 oz.
disposable propane cylinders. The
LP-gas cylinder(s) used with stoves
must be constructed and marked in
accordance with the specications for
LP-gas cylinders of the U.S. Department
of Transportation or Transport Canada,
CAN/CSA B339.
SERVICE SAFETY
• Keep all connections and fittings
clean. Inspect propane cylinder
and stove propane connections for
damage before attaching.
• During set up, check all connections
and fittings for leaks using soapy
water. Bubbles indicate a leak. Never
use a flame.
CAUTION
The Coleman Company, Inc., a Jarden Corporation company/
une compagnie de Jarden Corporation (NYSE:JAH)
The Coleman Company, Inc. • 3600 North Hydraulic • Wichita, KS 67219 U.S.A.
1-800-835-3278 TDD: 1-316-832-8707
www.coleman.com
English - 1 English - 2 English - 3 English - 4
4010016264 (ECN20022590-04)
IMPORTANT
Read this manual carefully before assembling, using or servicing these
stoves. Keep this manual for future reference. If you have questions
about assembly, operation, servicing or repair of these stoves, please
call Coleman in the United States at 1-800-835-3278 or
TDD: 1-316-832-8707 and in Canada at 1-800-387-6161.
IMPORTANT
Lisez attentivement ce manuel avant d’assembler, d’utiliser ou de
réparer le réchaud et gardez-le pour référence ultérieure. Pour toute
question en ce qui concerne l’assemblage, le fonctionnement,
l’entretien ou la réparation, appelez Coleman au 1-800-835-3278 ou
ATS 1-316-832-8707 aux États-Unis et au 1-800-387-6161 au Canada.
Note:
Propane tank is not included.
Remarque :
La bouteille de propane n’est pas incluse.
Propane Stoves
Réchauds à propane
Instructions for use
Notice d’emploi
© 2012 The Coleman Company, Inc
www.coleman.com
5459 Series
Standard Ignition
Allumage standard
Make sure stove is cool.
Move stove away from ame (including
pilot lights) and other ignition sources.
Remove propane cylinder from
regulator and replace protective cap
on cylinder. (Fig. 12)
MAINTENANCE
• Wipe clean with soft cloth and mild
dish detergent. Do not use
abrasives. (Fig. 14)
Remove regulator from stove. (Fig. 13)
Fig. 12
Fig. 13
Close both burner valves rmly. (Fig. 11)
Fig. 11
Fig. 14
For storage or transport, the regulator
may be located below the heat
shields. (Fig. 15)
Fig. 15
Item Part No. Description
1 5010001227 Grate & Screw
2 5010001193 Burner Assembly & Screw
3 R430B565T Regulator Assembly
4 R413-149T Knob & Screw
5 5010001194 Steel Wire Leg
6 5010001192 Lid Assembly (For Stove with lid only)
1
2
6
3
5
4
Fig. 9
Fig. 10
Screw regulator into stove hand
tight. (Fig. 5)
Propane cylinder correctly
installed. (Fig. 7)
Never operate stove with propane
cylinder in an inverted position. (Fig. 8)
Fig. 5
Fig. 6
Remove plastic cap from top of
propane bottle and screw propane
bottle into regulator hand tight. (Fig. 6)
Fig. 7
Fig. 8
• Keep stove area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
• Do not obstruct the flow of
combustion and ventilation air.
• A good flame should be blue with
minimal yellow tip. Some yellow tips
on flames are acceptable as long as
no carbon or soot deposits appear.
Input: 7,000 BTU/h per burner
Category: Pressure regulated propane
Fuel: 16.4 oz. disposable propane cylinders
Regulator: 5430-565
Install grates as shown. (Fig. 3)
Close both burner valves rmly. (Fig. 4)
Open the lid by hands. (Fig. 2)
Fig. 2
Fig. 3
Fig. 4
Remove components from carton. (Fig. 1)
1. Lid (Optional )
2. Screw
3. Grate
4. Regulator
NOTE: Lid can’t be used for the non-lidded
stove model.
Fig. 1
1
2
3
4
© 2012 The Coleman Company, Inc. All rights reserved. Coleman
®
,
and are registered trademarks of The
Coleman Company, Inc.
© 2012 The Coleman Company, Inc. Tous droits réservés. Coleman
®
, et sont des marques déposées de
The Coleman Company, Inc.
ANSI Z21.72-2011/CSA 11.2-2011
®
®
CE
RT
IFIED